A11VO系列力士樂軸向柱塞泵安裝和試運行說明
發布時間：2023-04-18 編輯:力士樂rexroth
A11VO系列力士樂軸向柱塞泵安裝和試運行說明：
概述
泵殼在試運行和工作過程中必須充滿油液(充滿殼體內)。
試運行必須在低速和無載的情況下進行，直到系統完全排氣。
長期停機時，泵殼體內的油液會通過工作管路泄空。再次使用時，必須保證泵殼體內充滿油液。
泵殼體內的泄漏油通過最高位的泄油口排回油箱。S油口的最低吸油壓力不得低于0.8bar絕對壓力(無升壓泵)或低于0.5bar
絕對壓力(帶升壓泵)。
下置式安裝
油泵低于油箱內最低液面(標準)
任意安裝位置
安裝位置“軸朝上”
必須在試運行期間確保泵殼完全充滿油液。如果軸承處出現氣泡，會損壞軸向柱塞泵。
安裝步驟:
試運行前，從最高位的泄油口T1、T2和R使軸向柱塞泵充滿油液。
建議給吸油管路也充油。
低速(起動器轉速)啟動泵，直到泵全部充滿油液。
吸油管及泄油管在油箱內的最小浸沒深度為200mm(相對于油箱最低油位高度)。
上置式安裝.
泵的安裝位置高于油箱的最低液位。
如果泵停機時間較長，殼體油液可能會經工作管路泄掉(空氣經軸封進入殼體)。這時，如果重新啟動泵，軸承將無法得到充分潤滑。
啟動前，軸向柱塞泵必須通過最高位的泄油口充滿油液(通過油口R排氣)。可通過在泄油管路安裝-一個單向閥(開啟壓力0.5 bar)來避免殼體油液的泄漏。通過工作油口的泄漏可采用特殊設計的控制接板來解決。
安裝位置“軸水平”及“軸朝上”;
安裝位置“軸朝上”;
A1 1VLO型(帶升壓泵)不能采用上置式安裝。
安裝步驟見下置式安裝
上置式安裝的額外步驟:
最大允許吸油高度hmax=800mm
油口S的最低允許壓力(最低吸油壓力)
-對于帶壓力控制、排量限制器、HD和EP控制的控制選項，排:量設定值必須為:Vg25%●Vgmax。
建議采用帶“鵝頸”的吸油管。
A11VO系列力士樂軸向柱塞泵訂貨號及型號：
R902050288 力士樂柱塞泵A11VO190DRG/11R-NPD12K02 R902094298 力士樂柱塞泵A11VO130LRDS/10R-NZD12K07
R902050289 力士樂柱塞泵A11VO130DRS/10L-NSD12K17 R902096203 力士樂柱塞泵A11VO75LRDU2/10R-NSD12K01P
R902050317 力士樂柱塞泵A11VO40DR/10L-NZC12K01 R902097263 力士樂柱塞泵A11VO75LR/10R-NSD12K01
R902050335 力士樂柱塞泵A11VO95LG1DS/10L-NZD12N00 R902097334 力士樂柱塞泵A11VO40LRDS/10R-NTC12K01
R902050392 力士樂柱塞泵A11VO40DRG/10R-NSC12K02 R902097440 力士樂柱塞泵A11VO95LRDS/10L-NSD12K04
R902050449 力士樂柱塞泵A11VO60DRS/10R-NZC12K01 R902097555 力士樂柱塞泵A11VO260LRCS/11R-NZD12K07
R902051084 力士樂柱塞泵A11VO130LRDS/10L-NSD12N00 R902097818 力士樂柱塞泵A11VO260DRS/11R-NZD12K84R
R902051109 力士樂柱塞泵A11VO130LRDS/10R-NZD12K04 R902097819 力士樂柱塞泵A11VO190DRS/11R-NZD12N00R
R902051297 力士樂柱塞泵A11VO190LRDH1/11R-NSD12K02 R902097867 力士樂柱塞泵A11VO60LRDS/10R-NZC12K02
R902051353 力士樂柱塞泵A11VO60HD1D/10L-NZC12K61 R902097933 力士樂柱塞泵A11VO60LRD/10R-NSC12N00
R902051395 力士樂柱塞泵A11VO95HD1D/10L-NZD12K82 R902097939 力士樂柱塞泵A11VO260LRH1/11R-NPD12K24 K
R902051398 力士樂柱塞泵A11VO60DRS/10R-NSC12K04 R902097940 力士樂柱塞泵A11VO260LRH1/11R-NPD12K24
R902052809 力士樂柱塞泵A11VO75HD2D/10R-NZD12N00 R902097947 力士樂柱塞泵A11VO130LRD/10R-NSD12K07
R902052812 力士樂柱塞泵A11VO130LRDH6/10R-NZD12K83 R902099584 力士樂柱塞泵A11VO260LRDCH1/11R-NZD12K07V
R902052813 力士樂柱塞泵A11VO130LRDH6/10R-NZD12K81 R902099617 力士樂柱塞泵A11VO60EP2/10R-NSC12K07H
R902052934 力士樂柱塞泵A11VO95DRS/10L-NSD12K07 R902099820 力士樂柱塞泵A11VO260LRDH2/11R-NZD12K81
R902052940 力士樂柱塞泵A11VO95LRG/10R-NPD12N00 R902100847 力士樂柱塞泵A11VO95DRG/10L-NSD12K02
R902053105 力士樂柱塞泵A11VO190DRS/11L-NSD12K02 R902100920 力士樂柱塞泵AA11VO95LRDS/10R-NSD62K07
R902053107 力士樂柱塞泵A11VO130LRDS/10L-NZD12K02 R902100957 力士樂柱塞泵A11VO190EP2G/11R-NZD12K84P
R902053145 力士樂柱塞泵A11VO95DRS/10L-NSD12K02 R902100958 力士樂柱塞泵A11VO190EP2G/11R-NZD12N00P
R902053473 力士樂柱塞泵A11VO190DRS/11R-NPD12K84 R902100972 力士樂柱塞泵A11VO190EP2G/11R-NZD12K17P
R902056234 力士樂柱塞泵A11VO95LRDH1/10L-NZD12K02 R902102093 力士樂柱塞泵AA11VO60DRG/10L-NSC62N00
R902056409 力士樂柱塞泵A11VO95LRH2/10L-NSD12K01 R902102134 力士樂柱塞泵A11VO260LRDS/11R-NSD12K04
R902056421 力士樂柱塞泵A11VO60LR/10L-NZC12K61 R902102317 力士樂柱塞泵A11VO130LG2D/10L-NZD12K01
R902056658 力士樂柱塞泵A11VO260DRL/11R-NZD12K84 R902102472 力士樂柱塞泵A11VO145LRDH1/11R-NZD12K01
R902059487 力士樂柱塞泵A11VO260DRS/11L-NZD12N00 R902104058 力士樂柱塞泵A11VO130LRDS/10L-NZD12K83
R902059491 力士樂柱塞泵A11VO190DRS/11L-NZD12K84 R902104092 力士樂柱塞泵A11VO130EP2G/10R-NPD12K07P
R902061802 力士樂柱塞泵A11VO95LR3DS/10R-NZD12K07 R902104107 力士樂柱塞泵A11VO130LRH1/10R-NZD12K02
R902061876 力士樂柱塞泵A11VO130LRDS/10R-NSD12K02 R902104176 力士樂柱塞泵A11VO40DR/10R-NPC12K02V
R902062514 力士樂柱塞泵A11VO190HD2D/11R-NSD12K04 R902104196 力士樂柱塞泵A11VO145LRDS/11R-NZD12K07
R902062557 力士樂柱塞泵A11VO95LRDS/10L-NPD12K01 R902104200 力士樂柱塞泵A11VO145LRDH1/11R-NSD12K52
R902062569 力士樂柱塞泵A11VO60LG1DS/10R-NSC12K07 R902104245 力士樂柱塞泵A11VO75DRG/10L-NSD12K02
R902062603 力士樂柱塞泵A11VO190LRDH2/11R-NZD12K01 R902104681 力士樂柱塞泵AA11VO95LRDS/10R-NSD62K04
R902062636 力士樂柱塞泵A11VO95LRS/10R-NZD12K01 R902104963 力士樂柱塞泵A11VO95LE2S/10R-NZD12K82H
R902062876 力士樂柱塞泵A11VO95DRL/10R-NPD12N00 R902105096 力士樂柱塞泵A11VO130LRDS/10R-NSD12K07 ES
R902063128 力士樂柱塞泵A11VO260LRDS/11R-NPD12N00 R902105103 力士樂柱塞泵A11VO145LRDS/11R-NZD12K01
R902063137 力士樂柱塞泵A11VO60DR/10L-NSC12K07 R902105139 力士樂柱塞泵A11VO95LR3S/10R-NZD12K82
R902063171 力士樂柱塞泵A11VO260DR/11R-NZD12N00 R902105149 力士樂柱塞泵A11VO190DR/11R-NSD12N00
R902063284 力士樂柱塞泵A11VO40DRS/10L-NSC12K02 R902105174 力士樂柱塞泵A11VO130LG2D/10L-NZD12K01
R902063323 力士樂柱塞泵A11VO130LRDS/10R-NSD12K01 R902105335 力士樂柱塞泵A11VO190DRG/11R-NZD12K84
R902064306 力士樂柱塞泵A11VO260DRS/11R-NZD12K67 R902105412 力士樂柱塞泵A11VO75DRL/10L-NSD12K07
R902064473 力士樂柱塞泵A11VO260LRDU2/11R-NPD12K67VH R902105416 力士樂柱塞泵A11VO95DRS/10R-NZD12K61
R902064562 力士樂柱塞泵A11VO190LRD/11R-NPD12N00 R902106175 力士樂柱塞泵A11VO260DRS/11L-NZD12K67
R902064582 力士樂柱塞泵A11VO190LRDS/11R-NSD12N00 R902106193 力士樂柱塞泵A11VO95EP2D/10L-NSD12K02P
R902064882 力士樂柱塞泵A11VO130DRS/10L-NSD12K02 R902106276 力士樂柱塞泵A11VO75LRDS/10R-NSD12N00
R902064919 力士樂柱塞泵A11VO95DR/10R-NSD12N00 R902106318 力士樂柱塞泵A11VO260LRDS/11R-NPD12K24 K
R902066018 力士樂柱塞泵AA11VO190LG2S/11R-NZGXXK80R R902108257 力士樂柱塞泵A11VO145LRDS/11R-NZG12K83
R902066206 力士樂柱塞泵A11VO260DR/11L-NZD12K84 R902108274 力士樂柱塞泵A11VO145LRDS/11R-NZD12N00
R902066245 力士樂柱塞泵A11VO95DRS/10L-NSD12K04 R902108328 力士樂柱塞泵A11VO95LE2S2/10L-NZD12N00P
R902066279 力士樂柱塞泵A11VO95DRS/10R-NSD12N00 R902108380 力士樂柱塞泵A11VO190LRDS/11R-NPD12K83
R902066766 力士樂柱塞泵A11VO95LRDS/10R-NSD12K07 R902108393 力士樂柱塞泵A11VO145LRDS/11R-NZD12K17
R902066783 力士樂柱塞泵A11VO260DRG/11R-NSD12K02 R902108414 力士樂柱塞泵A11VO145DRS/11R-NPD12N00
R902066872 力士樂柱塞泵A11VO190LRS/11R-NZD12K02 R902110516 力士樂柱塞泵A11VO145LRDS/11L-NZD12K83
R902067138 力士樂柱塞泵A11VO95DRS/10R-NZD12K82 R902110517 力士樂柱塞泵A11VO145DRS/11L-NZD12N00
R902067288 力士樂柱塞泵A11VO75LR/10R-NSD12N00 R902110978 力士樂柱塞泵A11VO75EP2G/10R-NZD12K81P
R902067317 力士樂柱塞泵A11VO260LRH2/11R-NPD12N00 R902112468 力士樂柱塞泵A11VO130DRL/10R-NSD12K17
R902068245 力士樂柱塞泵A11VO95DRS/10R-NZD12K79 R902112469 力士樂柱塞泵A11VO130DRL/10R-NSD12K04
R902068353 力士樂柱塞泵A11VO260DRL/11R-NPD12K67 R902112495 力士樂柱塞泵A11VO75LRDS/10L-NZD12K02
R902068354 力士樂柱塞泵A11VO260DRL/11R-NZD12N00 R902112552 力士樂柱塞泵A11VO190DRG/11L-NTD12N00
R902068372 力士樂柱塞泵A11VO145LR3DS/11R-NZD12K01 R902112587 力士樂柱塞泵A11VO130DRL/10L-NZD12K82
R902068394 力士樂柱塞泵A11VO260DRS/11R-NPD12K83 R902112591 力士樂柱塞泵A11VO75EP2G/10R-NZD12K01P
R902069145 力士樂柱塞泵A11VO60LRD/10L-NSC12N00 R902112749 力士樂柱塞泵A11VO95DRG/10R-NPD12N00R
R902069239 力士樂柱塞泵A11VO260LRGH6/11L-NZD12K84R R902112885 力士樂柱塞泵A11VO130DRS/10R-NZD12K82
R902070003 力士樂柱塞泵A11VO190LR/11L-NPD12N00 R902117017 力士樂柱塞泵A11VO95LRD/10R-NSD12K07
R902070008 力士樂柱塞泵A11VO190LR3D/11R-NZD12N00 R902117207 力士樂柱塞泵AA11VO95LE1S/10R-NSD62K17P
R902070143 力士樂柱塞泵A11VO260LRDCH1/11R-NZD12K67V R902117208 力士樂柱塞泵AA11VO95LE1S/10R-NSD62K02P
R902070144 力士樂柱塞泵A11VO260LRDCH1/11R-NZD12N00V R902117347 力士樂柱塞泵A11VO190DRS/11R-NZD12K83
R902070183 力士樂柱塞泵A11VO130LRDH1/10R-NZD12K01 R902117425 力士樂柱塞泵A11VO95LRDS/10R-NZG12K01
R902070282 力士樂柱塞泵A11VO95DRG/10R-NPD12K01 R902117465 力士樂柱塞泵A11VO95LRS/10L-NZD12N00
R902071539 力士樂柱塞泵A11VO95HD1D/10L-NZD12K01 R902118040 力士樂柱塞泵A11VO190LR/11R-NPD12K24
R902071783 力士樂柱塞泵A11VO130DRS/10R-NZD12K01 R902118095 力士樂柱塞泵A11VO95LE1X/10R-NZG12K04X
R902073004 力士樂柱塞泵A11VO40DRG/10R-NSC12K01 R902118356 力士樂柱塞泵A11VO60LRDH1/10R-NSC12K01
R902073074 力士樂柱塞泵A11VO260LRDS/11R-NPD12K24 R902118358 力士樂柱塞泵A11VO190LRDU2/11R-NPD12K01P
R902073239 力士樂柱塞泵A11VO60DR/10R-NSC12K01 R902118445 力士樂柱塞泵A11VO145DRS/11R-NZD12K81
R902073261 力士樂柱塞泵A11VO190DRG/11L-NTD12K02 R902118450 力士樂柱塞泵A11VO40EP2D/10L-NZC12K02P
R902073301 力士樂柱塞泵A11VO95HD2D/10R-NZD12K07 R902118472 力士樂柱塞泵A11VO60HD1D/10R-NSC12N00
R902073434 力士樂柱塞泵A11VO260DRL/11L-NZD12N00 R902119004 力士樂柱塞泵A11VO60HD1D/10R-NZC12N00
R902073437 力士樂柱塞泵A11VO130DRL/10L-NZD12N00 R902119011 力士樂柱塞泵A11VO130LE1X/10R-NZG12K61X
R902073480 力士樂柱塞泵A11VO190LRDH1/11L-NZD12N00 R902119013 力士樂柱塞泵A11VO145LE1X/11R-NZG12K01X
R902074455 力士樂柱塞泵A11VO190DRS/11L-NZD12K24 R902119063 力士樂柱塞泵A11VO145LRDG/11R-NPD12N00V
R902074543 力士樂柱塞泵A11VO190DR/11R-NPD12K01 R902119065 力士樂柱塞泵A11VO60EP2S/10R-NZC12K61H
R902074547 力士樂柱塞泵A11VO190DRG/11R-NPD12K04 R902119066 力士樂柱塞泵A11VO60EP2S/10R-NZC12N00H
R902074580 力士樂柱塞泵A11VO145LRDS/11R-NSD12K02 R902119067 力士樂柱塞泵A11VO60LRS/10R-NZC12K61
R902074696 力士樂柱塞泵A11VO130LR3S/10R-NZG12K01 R902119068 力士樂柱塞泵A11VO60LRS/10R-NZC12N00
